Allied Vision Technologies F-131C Manual de Instruções

Technical ManualGigE Vision CamerasV3.0.015 January 2015Allied Vision Technologies GmbHTaschenweg 2aD-07646 Stadtroda / GermanyAllied Vision Mako

Mako Technical Manual V3.0.010Camera cleaning instructionsCamera cleaning instructionsThis chapter describes safety instructions/cautions valid for M

Mako Technical Manual V3.0.011Camera cleaning instructionsIs it an impurity? – Identifying impuritiesIf you observe any image artefacts in your video

Mako Technical Manual V3.0.012Camera cleaning instructionsPlease carefully remove the filter/protection glass and clean it on both sides using the te

Mako Technical Manual V3.0.013Camera cleaning instructions3. Wipe the glass surface with a spiral motion from the center to the rim. Normally, severa

Mako Technical Manual V3.0.014About Mako GigE camerasAbout Mako GigE camerasMako Mako cameras have a Gigabit Ethernet interface.GigE GigE is the abbr

Mako Technical Manual V3.0.015ConformityConformityAllied Vision Technologies declares under its sole responsibility that all stan-dard cameras of the

Mako Technical Manual V3.0.016SpecificationsSpecificationsMako G-030B/CCautionBefore operating any Allied Vision camera, read the safety instruction

Mako Technical Manual V3.0.017SpecificationsOn-board FIFO 64 MByte, up to 99 frames at full resolution, Mono8/Bayer8, and a GevSCPSPacketSize = 8192

Mako Technical Manual V3.0.018Specifications Figure 7: Spectral sensitivity of Mako G-030B Figure 8: Spectral sensitivity of Mako G-030C0%10%20%30%40

Mako Technical Manual V3.0.019SpecificationsMako G-032B/CFeature SpecificationResolution 658 x 492Sensor SONY IT CCD ICX424AL/AQ with HAD microlensT

Mako Technical Manual V3.0.02Legal noticeFor customers in the U.S.A.This equipment has been tested and found to comply with the limits for a Class B

Mako Technical Manual V3.0.020Specifications Figure 9: Spectral sensitivity of Mako G-032B (without protection/cover glass) Figure 10: Spectral sensi

Mako Technical Manual V3.0.021SpecificationsMako G-050B/CFeature SpecificationResolution812 x 614Sensor SONY CCD ICX693ALA/AQA with Super HAD CCD IIT

Mako Technical Manual V3.0.022Specifications Figure 11: Spectral sensitivity of Mako G-050B (without protection/cover glass) Figure 12: Spectral sens

Mako Technical Manual V3.0.023SpecificationsMako G-095B/CFeature SpecificationResolution 1292 x 734Sensor SONY IT CCD ICX692ALA/AQA with EXview HAD

Mako Technical Manual V3.0.024Specifications Figure 13: Spectral sensitivity of Mako G-095B (without protection/cover glass) Figure 14: Spectral sens

Mako Technical Manual V3.0.025SpecificationsMako G-125B/CFeature SpecificationResolution 1292 x 964Sensor SONY IT CCD ICX445ALA/AQA with EXview HAD

Mako Technical Manual V3.0.026Specifications Figure 15: Spectral sensitivity of Mako G-125B (without protection/cover glass) Figure 16: Spectral sens

Mako Technical Manual V3.0.027SpecificationsMako G-131B/CFeature SpecificationResolution 1280 x 1024Sensor e2v EV76C560Type CMOS ProgressiveSensor si

Mako Technical Manual V3.0.028Specifications Figure 17: Spectral sensitivity of Mako G-131B Figure 18: Spectral sensitivity of Mako G-131C0%10%20%30%

Mako Technical Manual V3.0.029SpecificationsMako G-192B/CFeature SpecificationResolution 1600 x 1200Sensor e2v EV76C570Type CMOS ProgressiveSensor si

Mako Technical Manual V3.0.03ContentsContacting Allied Vision ...

Mako Technical Manual V3.0.030Specifications Figure 19: Spectral sensitivity of Mako G-192B Figure 20: Spectral sensitivity of Mako G-192C0%5%10%15%2

Mako Technical Manual V3.0.031SpecificationsMako G-223B/C (NIR)Feature SpecificationResolution 2048 x 1088Sensor CMV2000 with microlenses and global

Mako Technical Manual V3.0.032Specifications Figure 21: Spectral sensitivity of Mako G-223B (NIR) Figure 22: Spectral sensitivity of Mako G-223C (wit

Mako Technical Manual V3.0.033SpecificationsMako G-419B/C (NIR)Feature SpecificationResolution 2048 x 2048Sensor CMV4000 with microlenses and global

Mako Technical Manual V3.0.034Specifications Figure 23: Spectral sensitivity of Mako G-419B (NIR) Figure 24: Spectral sensitivity of Mako G-419C (wi

Mako Technical Manual V3.0.035Camera smart featuresCamera smart featuresAllied Vision cameras support a number of standard and extended features. The

Mako Technical Manual V3.0.036Filter and lensesFilter and lensesIR cut filterColor cameras are equipped with IR cut filter. The following illustratio

Mako Technical Manual V3.0.037Filter and lensesThe following table lists selected image formats in width x height depending on camera type, distance

Mako Technical Manual V3.0.038Filter and lensesMako G-095Mako G-125Mako G-131Mako G-192Focal length for type 1/3 sensor Distance = 500 mm Distance =

Mako Technical Manual V3.0.039Filter and lensesMako G-223Mako G-419Focal length for type 2/3*sensors Distance = 500 mm Distance = 1000 mm4.8 mm 1162

Mako Technical Manual V3.0.04Mako G-419...

Mako Technical Manual V3.0.040Camera dimensionsCamera dimensionsTripod adapterThis tripod adapter (Allied Vision order number 4807) ...• ... can be u

Mako Technical Manual V3.0.041Camera dimensionsCross section: C-Mount • All color Mako cameras are equipped with the same IR cut filter type.• Mako G

Mako Technical Manual V3.0.042Camera dimensionsCross section: CS-MountChoose protection glass or filter according to the Allied Vision Modular Con-ce

Mako Technical Manual V3.0.043Camera dimensionsAdjustment of the C-Mount and CS-MountThe dimensional adjustment cannot be done by the customer. All m

Mako Technical Manual V3.0.044Camera interfacesCamera interfacesThis chapter describes the Gigabit Ethernet port, inputs and outputs, and trig-ger fe

Mako Technical Manual V3.0.045Camera interfacesGigabit Ethernet portThe Gigabit Ethernet port conforms to the IEEE 802.31000BASE-T standard for Gigab

Mako Technical Manual V3.0.046Camera interfacesMako input descriptionMako input block diagramThe input can be connected directly to the system for vo

Mako Technical Manual V3.0.047Camera interfacesMako output descriptionMako block diagram Figure 36: Mako output block diagramCaution• Maximum 20 mA

Mako Technical Manual V3.0.048Camera interfacesFor all Mako models:Test conditionsOutput: external 2.4 k resistor to GND, Camera Out Power set to 12

Mako Technical Manual V3.0.049Camera interfacesControl signalsThe inputs and outputs of the camera can be configured by software. The differ-ent mode

Mako Technical Manual V3.0.05Contacting Allied VisionContacting Allied VisionInfo• Technical information:http://www.alliedvision.com• Support:suppor

Mako Technical Manual V3.0.050Camera interfacesImaging Imaging is high when the camera image sensor is either exposing and/or reading out data.Acquir

Mako Technical Manual V3.0.051Camera interfacesTrigger timing diagramThe following diagram explains the trigger concept in general.Notes on triggerin

Mako Technical Manual V3.0.052Camera interfacesTrigger rules•The end of exposure will always trigger the next readout.•The end of exposure must alway

Mako Technical Manual V3.0.053Description of the data pathDescription of the data pathThe following diagrams illustrate the data flow and the bit res

Mako Technical Manual V3.0.054Description of the data pathMako G-131B, Mako G-192BMako G-223B, Mako G-223 NIR, Mako G-419B, Mako G-419 NIR Figure 44:

Mako Technical Manual V3.0.055Description of the data pathMako color camerasMako with CCD sensorsMako G-032C, Mako G-050C, Mako G-095C, Mako G-125CMa

Mako Technical Manual V3.0.056Description of the data pathMako G-131C, Mako G-192CMako G-223C, Mako G-419C Figure 48: Block diagram of Mako G-131 and

Mako Technical Manual V3.0.057Description of the data pathCamera featuresThis chapter lists the camera and driver features for Mako cameras as displa

Mako Technical Manual V3.0.058Description of the data pathOffPreviousFrameTriggerSelectorFrameStartAcquisitionStartAcquisitionEndAcquisitionRecordTri

Mako Technical Manual V3.0.059Description of the data pathContinuousExposureAutoControlExposureAutoAdjustTolExposureAutoAlgExposureAutoMaxExposureAut

Mako Technical Manual V3.0.06IntroductionIntroductionThis Mako Technical Manual describes in depth the technical specifications, dimensions, all pixe

Mako Technical Manual V3.0.060Description of the data pathLUTLoadAllLUTModeLuminanceRedGreenBlueLUTSaveAllLUTSelectorLUT1LUTValueSaturationWhitebalan

Mako Technical Manual V3.0.061Description of the data pathEventLineRisingEdgeFrameIDEventLineRisingEdgeTimestampEventOverflowFrameIDEventOverflowTime

Mako Technical Manual V3.0.062Description of the data pathPersistent Default GatewayPersistent IP AddressPersistent Subnet MaskStreamBytesPerSecondSt

Mako Technical Manual V3.0.063Description of the data pathSyncOut3SyncOutSourceGPOAcquisitionTriggerReadyFrameTriggerReadyExposingFrameReadoutImaging

Mako Technical Manual V3.0.064Description of the data pathDeviceScanTypeDeviceVendorNameFirmwareVerBuildFirmwareVerMajorFirmwareVerMinorSensorBitsSen

Mako Technical Manual V3.0.065Description of the data pathFrame memoryAn image is normally captured and transported in consecutive steps. The image i

Mako Technical Manual V3.0.066Resolution and ROI frame ratesResolution and ROI frame ratesThis section charts the resulting frame rate from changing

Mako Technical Manual V3.0.067Resolution and ROI frame ratesMako G-030B/C: ROI frame ratesMaximum frame rate at full resolution according to formula:

Mako Technical Manual V3.0.068Resolution and ROI frame ratesMako G-032B/C: ROI frame ratesMaximum frame rate at full resolution according to formula:

Mako Technical Manual V3.0.069Resolution and ROI frame ratesMako G-050B/C: ROI frame ratesMaximum frame rate at full resolution according to formula:

Mako Technical Manual V3.0.07Introductioncontinued from last pageV2.0.3 2013-Nov-27 • Updated gain control values for Mako G-223B/C (NIR) and Mako G-

Mako Technical Manual V3.0.070Resolution and ROI frame ratesMako G-095B/C: ROI frame ratesMaximum frame rate at full resolution according to formula:

Mako Technical Manual V3.0.071Resolution and ROI frame ratesMako G-125B/C: ROI frame ratesMaximum frame rate at full resolution according to formula:

Mako Technical Manual V3.0.072Resolution and ROI frame ratesMako G-131B/C: ROI frame rates*There will be an increase in frame rate with reduced width

Mako Technical Manual V3.0.073Resolution and ROI frame ratesMako G-192B/C: ROI frame rates*There will be an increase in frame rate with reduced width

Mako Technical Manual V3.0.074Resolution and ROI frame ratesMako G-223B/C: ROI frame rates*There will be an increase in frame rate with reduced width

Mako Technical Manual V3.0.075Resolution and ROI frame ratesMako G-419B/C: ROI frame rates*There will be an increase in frame rate with reduced width

Mako Technical Manual V3.0.076AppendixSensor position accuracy of Mako camerasMethod of positioningOptical alignment of the photo sensitive sensor ar

Mako Technical Manual V3.0.077IndexIndexAacquiring (signal) ... 50acquisition stream ...

Mako Technical Manual V3.0.078IndexOOutput block diagram ... 50Output signals ...

Mako Technical Manual V3.0.08IntroductionConventions used in this manualTo give this manual an easily understood layout and to emphasize important in

Mako Technical Manual V3.0.09IntroductionBefore operationTarget group This Technical Manual is the guide to detailed technical information of the cam